Is Super Orb enough to cool 1.2 GHz T-bird
 

Under a full load the CPU temp peaks at about 65 degrees Celsius. Is this bad?
I am using an AOpen HX08 Case with a KT7A raid motherboard and two 80mm case fans. Should I create a blow hole in the case. Fans in a blow hole blow air in right?

ouch...65C?? That's bad.
I would get a global WinFOP38 (pretty loud cooler) or a vantec socket A with delta fan cooling setup.
I initially ran my 1.0G tbird with a thermaltake orb at 55-60C....then i upgraded to a fop38 and dropped my temps to 40C...much better. Then when prices dropped on cpus...i say "screw it" and bought a 1.2 tbird. It hits 42-43C at full load iwth my fop38....i changed it out for the vantec cooler (much easier fastening clip imho) and the temps are similar. The vantec cooler might be a few decibles quieter....i can't really tell.
Both coolers are around $20-$25. Well worth it as running your cpu at a cooler temp will not only prolong its lifespan, but will allow you to overclock should you choose to venture down that road http://www.procooling.com/ubb/smile.gif

------------------
1.2Tbird @1456 with winter air cooling...yeah baby!

The Taisol Forged is the bomb diggity in my opinion. No ear shattering fan, but damn good cooling. If you want the best combo of performance, buy a volcano II and take the fan off, then put it on the Taisol. 36 cfm coolin' and quiet to boot. I like my PAL6035 myself.

Yeah... I'm a fan of that Taisol too... best socket A mounting system i've seen.